Prediction model for settlement caused by damage of underground pipelines and its experimental verification

LIU Cheng-yu; CHEN Bo-wen; LIN Wei; LUO Hong-lin

doi:10.11779/CJGE202103003

Volume 43 Issue 3

Turn off MathJax

Article Contents

Abstract

References

Chinese Journal of Geotechnical Engineering > 2021 > 43(3): 416-424. > DOI: 10.11779/CJGE202103003

LIU Cheng-yu, CHEN Bo-wen, LIN Wei, LUO Hong-lin. Prediction model for settlement caused by damage of underground pipelines and its experimental verification[J]. Chinese Journal of Geotechnical Engineering, 2021, 43(3): 416-424. DOI: 10.11779/CJGE202103003

Citation:

PDF (1308 KB)

Prediction model for settlement caused by damage of underground pipelines and its experimental verification

1.
College of Environment and Resources, Fuzhou University, Fuzhou 350116, China
2.
Research Center of Geological Engineering, Fuzhou 350116, China

More Information

Received Date: March 08, 2020
Available Online: December 04, 2022

Graphical Abstract

Abstract

Abstract

A set of test system of ground settlement caused by damage of pipelines in water-rich sand layers is designed. For 11 kinds of soil samples with frame diameter d₉₀ of 1.45~8.45 mm under 6 kinds of permeability ratio drops and full flow velocity of pipelines, the laws of ground settlement induced by seepage erosion of soil mass are studied. On this basis, a prediction model for ground settlement induced by damage of underground pipelines is proposed. The results show: (1) Whether the pipeline damage will induce settlement in the water-rich sand layers is mainly determined by the soil skeleton particle size d₉₀, the diameter D of the damaged mouth and the thickness span ratio h_S/D. The maximum value of the soil skeleton particle size d₉₀ that causes the settlement should meet both the conditions of the diameter D of the damaged mouth and the thickness span ratio h_s/D, and take the smaller value of the two. (2) In the water-rich sand layers, the area of pipeline damage-induced settlement is circular in plane and inverted triangle in section, and the slope angle is close to the saturated internal friction angle of soils. The top radius and settlement depth of settlement area increase with the increase of full flow velocity u and permeability ratio drop h_w/h_s, and decrease with the increase of thickness span ratio h_s/D. (3) Based on the Manning's formula, the prediction formulas for settlement radius and settlement depth are deduced, and are consistent with the test results in law and close to the test results in numerical value. They can be used to predict the settlement caused by damage of pipelines in water-rich sand layers.
- water-rich sand layer,
- pipeline damage,
- ground settlement,
- Manning's formula,
- prediction model

FullText(HTML)

References (22)

References

[1]	李涛, 张子真, 宗露丹. 地下空洞引起土质地层地陷的形成机制与预测研究[J]. 岩土力学, 2015, 36(7): 1995-2002. https://www.cnki.com.cn/Article/CJFDTOTAL-YTLX201507029.htm LI Tao, ZHANG Zi-zhen, ZONG Lu-dan. Formation mechanism and prediction of soil subsidence caused by underground cavities[J]. Rock and Soil Mechanics, 2015, 36(7): 1995-2002. (in Chinese) https://www.cnki.com.cn/Article/CJFDTOTAL-YTLX201507029.htm
[2]	胡聿涵, 白玉川, 徐海珏. 近10年中国城市道路塌陷原因及防治对策分析[J]. 公路, 2016(9): 130-135. https://www.cnki.com.cn/Article/CJFDTOTAL-GLGL201609036.htm HU Yi-han, BAI Yu-chuan, XU Hai-qi. Analysis of causes and prevention countermeasures of urban road collapse in China in Recent Ten Years[J]. Highway, 2016(9): 130-135. (in Chinese) https://www.cnki.com.cn/Article/CJFDTOTAL-GLGL201609036.htm
[3]	张成平, 岳跃敬, 王梦恕. 隧道施工扰动下管线渗漏水对地面塌陷的影响及控制[J]. 土木工程学报, 2015, 48(增刊1): 351-356. https://www.cnki.com.cn/Article/CJFDTOTAL-TMGC2015S1062.htm ZHANG Cheng-ping, YUE Yue-jing, WANG Meng-shu. Impact and control of pipeline leakage on ground collapse under tunnel construction disturbances[J]. Journal of Civil Engineering, 2015, 48(S1): 351-356. (in Chinese) https://www.cnki.com.cn/Article/CJFDTOTAL-TMGC2015S1062.htm
[4]	JONES G M A. The structural deterioration of sewers[C]//International Conference on the Planning, Construction, Maintenance and Operation of Sewer Systems, 1984, Reading, UK.
[5]	FENNER R A. The influence of sewer bedding arrangements on infiltration rates and soil migration[J]. Municipal Engineer, 1991, 8(2): 105-117.
[6]	张冬梅, 杜伟伟, 高程鹏. 间断级配砂土中管线破损引起的渗流侵蚀模型试验[J]. 岩土工程学报, 2018, 40(11): 2129-2135. https://www.cnki.com.cn/Article/CJFDTOTAL-YTGC201811025.htm ZHANG Dong-mei, DU Wei-wei, GAO Cheng-peng. Model test of seepage erosion caused by pipeline damage in intermittent graded sand[J]. Chinese Journal of Geotechnical Engineering, 2018, 40(11): 2129-2135. (in Chinese) https://www.cnki.com.cn/Article/CJFDTOTAL-YTGC201811025.htm
[7]	GUO S, ZHU D. Physical modeling on sand erosion around defective sewer pipes under the influence of groundwater[J]. Journal of Hydraulic Engineering, 2013, 139(12): 1247-1257. doi: 10.1061/(ASCE)HY.1943-7900.0000785
[8]	HILTON J E, CLEARY P W. Granular flow during hopper discharge[J]. Physical Review, 2011, 84(2): 307-315.
[9]	何勇兴. 地下管道漏损对周围土体侵蚀影响研究[D]. 杭州: 浙江大学, 2017. HE Yong-xing. Study on the Impact of Underground Pipeline Leakage on Surrounding Soil Erosion[D]. Hangzhou: Zhejiang University, 2017. (in Chinese)
[10]	TANG Y D Z, CHAN D H. Experimental study on submerged sand erosion through a slot on a defective pipe[J]. Journal of Hydraulic Engineering, 2017, 143(9): 1063-1072.
[11]	罗忠, 陈明辉. 富水砂层中暗挖隧道施工沉降控制技术[J]. 现代隧道技术, 2012, 49(2): 125-131. https://www.cnki.com.cn/Article/CJFDTOTAL-XDSD201202025.htm LUO Zhong, CHEN Ming-hui. Settlement control technology for undercut tunnel construction in water-rich sand layer[J]. Modern Tunnel Technology, 2012, 49(2): 125-131. (in Chinese) https://www.cnki.com.cn/Article/CJFDTOTAL-XDSD201202025.htm
[12]	刘成禹, 陈博文, 罗洪林, 等. 满流条件下管道破损诱发渗流侵蚀的试验研究[J]. 岩土力学, 2020, 41(1): 1-10. https://www.cnki.com.cn/Article/CJFDTOTAL-YTLX202001002.htm LIU Cheng-yu, CHEN Bo-wen, LUO Hong-lin, et al. Experimental study on pipeline-induced seepage erosion under full flow conditions[J]. Rock and Soil Mechanics, 2020, 41(1): 1-10. (in Chinese) https://www.cnki.com.cn/Article/CJFDTOTAL-YTLX202001002.htm
[13]	禹华谦. 工程流体力学：水力学[M]. 成都: 西南交通大学出版社, 2007. YU Hua-qian. Engineering Fluid Mechanics: Hydraulics[M]. Chengdu: Southwest Jiaotong University Press, 2007. (in Chinese)
[14]	建筑给水排水设计规范：GB 50015—2003[S]. 2009. Code for Design of Building Water Supply and Drainage: GB 50015—2003[S]. 2009. (in Chinese)
[15]	BEVERLOO W A, LENIGER H A, VELDE J V D. The flow of granular solids through orifices[J]. Chemical Engineering Science, 1961, 15(3): 260-269.
[16]	李云雁, 胡传荣. 试验设计与数据处理[M]. 北京: 化学工业出版社, 2005: 98-102. LI Yun-yan, HU Chuan-rong. Experiment Design and Data Processing[M]. Beijing: Chemical Industry Press, 2005: 98-102. (in Chinese)
[17]	TURKMEN S, OGUZEL N. Grouting a tunnel cave-in from the surface: a case study on Kurtkulagi irrigation tunnel, Turkey[J]. Tunneling and Underground Space Technology, 2003, 18(8): 365-375.
[18]	张顶立, 李倩倩, 房倩, 等. 隧道施工影响下城市复杂地层的变形机制及预测方法[J]. 岩石力学与工程学报, 2014, 33(12): 2504-2516. https://www.cnki.com.cn/Article/CJFDTOTAL-YSLX201412016.htm ZHANG Ding-li, LI Qian-qian, FANG Qian, et al. Deformation mechanism and prediction method for tunneling in complex urban groud condition[J]. Chinese Journal of Rock Mechanics and Engineering, 2014, 33(12): 2504-2516. (in Chinese) https://www.cnki.com.cn/Article/CJFDTOTAL-YSLX201412016.htm
[19]	罗小杰, 罗程. 沙漏型岩溶地面塌陷物理模型[J]. 中国岩溶, 2017, 36(1): 88-93. https://www.cnki.com.cn/Article/CJFDTOTAL-ZGYR201701011.htm LUO Xiao-jie, LUO Cheng. Physical model of hourglass karst surface collapse[J]. China Karst, 2017, 36(1): 88-93. (in Chinese) https://www.cnki.com.cn/Article/CJFDTOTAL-ZGYR201701011.htm
[20]	朱兴华, 崔鹏, 周公旦, 等. 稀性泥石流冲刷规律的试验研究[J]. 水利学报, 2012, 43(增刊2): 85-91. https://www.cnki.com.cn/Article/CJFDTOTAL-SLXB2012S2016.htm ZHU Xing-hua, CUI Peng, ZHOU Gong-dan, et al. Experimental study on the erosion rule of thin debris flow[J]. Journal of Hydraulic Engineering, 2012, 43(S2): 85-91. (in Chinese) https://www.cnki.com.cn/Article/CJFDTOTAL-SLXB2012S2016.htm
[21]	韦方强, 胡凯衡. 泥石流流速研究现状与发展方向[J]. 山地学报, 2009(5): 35-40. https://www.cnki.com.cn/Article/CJFDTOTAL-SDYA200905009.htm WEI Fang-qiang, HU Kai-heng. Research status and development trend of debris flow velocity[J]. Journal of Mountain Science, 2009(5): 35-40. (in Chinese) https://www.cnki.com.cn/Article/CJFDTOTAL-SDYA200905009.htm
[22]	BATHURST J C. At a site variation and minimum flow resistance for mointain rivers[J]. Journal of Hydrology, 2002, 269(4): 11-26.

[1]	ZHANG Hanchao, HU Shengxia, LI Hailong, LIN Sen, LI Wenna. Characteristics of triaxial deformation of Nanchang laterite[J]. Chinese Journal of Geotechnical Engineering, 2023, 45(S1): 119-122. DOI: 10.11779/CJGE2023S10012
[2]	DENG Mao-lin, ZHOU Jian, YI Qing-lin, ZHANG Fu-ling, HAN Bei, LI ZHUO Jun. Characteristics and mechanism of deformation of chair-shaped soil landslides in Three Gorges Reservoir area[J]. Chinese Journal of Geotechnical Engineering, 2020, 42(7): 1296-1303. DOI: 10.11779/CJGE202007013
[3]	YU Wei-jian, WANG Wei-jun, WEN Guo-hua, ZHANG Nong, WU Hai, ZHANG Yong-qing. Deformation mechanism and control technology of coal roadway under deep well and compound roof[J]. Chinese Journal of Geotechnical Engineering, 2012, 34(8): 1501-1508.
[4]	WU Hong-gang, MA Hui-min, BAO Gui-yu. Deformation mechanism of tunnel-slope system in shallow tunnels under unsymmetrical pressure[J]. Chinese Journal of Geotechnical Engineering, 2011, 33(zk1): 509-514.
[5]	YAN Zhi-xin, ZHANG Liu-ping, CAO Xiao-hong, ZHANG Xue-dong, CAI Han-cheng. D ynamic response and deformation mechanism of a bedding rock slope under earthquakes[J]. Chinese Journal of Geotechnical Engineering, 2011, 33(zk1): 54-58.
[6]	Deformation mechanism of secondary consolidation of natural clays[J]. Chinese Journal of Geotechnical Engineering, 2010, 32(7).
[7]	LI Jianlin, LIU Jie, WANG Lehua. Studies on deformation mechanism and rock mass stability of high slopes of Geheyan Power Station under multiple factors[J]. Chinese Journal of Geotechnical Engineering, 2007, 29(9): 1289-1295.
[8]	YIN Ji, WEI Jianhua, LI Xiangfan. Increment method to calculate dispalcement of composite soil nailled wall[J]. Chinese Journal of Geotechnical Engineering, 2007, 29(5): 755-759.
[9]	Miao Tiande, Liu Zhongyu, Ren Jiusheng. Deformation mechanism and constitutive relation of collapsible loess[J]. Chinese Journal of Geotechnical Engineering, 1999, 21(4): 383-387.
[10]	Wang Hongjin, Zhang Guoping, Zhou Keji. Effects Of Inherent and Induced Anisotropy on Strength and Deformation Characteristics of Compacted Cohesive Soil[J]. Chinese Journal of Geotechnical Engineering, 1996, 18(3): 1-10.